常见的洗地机问题？Discover蓄电池是最好的吗？

Common Floor Scrubber Problems
常见的洗地机问题

When functioning correctly, industrial floor scrubbers are fantastic investments.

They reduce cleaning time, eliminate industrial byproducts, and even protect flooring from costly damage.

如果运行正常，工业洗地机是极好的投资。它们减少了清洁时间，消除了工业副产品，甚至可以保护地板免受代价高昂的损坏。

Like any equipment, problems will arise over time. Learn more about seven of the most common floor scrubber problems below.

像任何设备一样，问题会随着时间的推移而出现。在下面详细了解七个最常见的洗地机问题。

Floor Scrubber Not Putting Out Water
洗地机不放水

One common issue is the floor scrubber not putting out water. Most models have an electric pump that delivers water to the floor.

Scrubbers use filters to clean that water before it is released. They also use an electronic system to pre-mix chemicals and control water flow.

一个常见的问题是洗地机不放水。大多数型号都有一个电动泵，可以将水输送到地板上。

洗涤器使用过滤器在水释放之前对其进行清洁。他们还使用电子系统来预混合化学品并控制水流。

If your machine isn’t releasing water, the solution could be as simple as filling the tank. Make sure the water in the tank is at the fill line.

如果您的机器没有放水，解决方案可能就像加满水箱一样简单。确保水箱中的水在填充线处。

If this isn’t the issue, check tank valves and hoses for blockages. A clogged hose can prevent water from coming through.

Your floor scrubber not putting out water could also be caused by a clogged tank filter.

如果这不是问题，请检查水箱阀门和软管是否堵塞。堵塞的软管会阻止水通过。您的洗地机不放水也可能是由水箱过滤器堵塞引起的。

Check if this is responsible for the floor scrubber not putting out water by cleaning the inline solution filter thoroughly.

Turn your scrubber’s water level setting to the highest option and run the machine. Disconnect the filter. If water does not pour out, there is a clog.

通过彻底清洁在线溶液过滤器来检查这是否是洗地机不排水的原因。

将洗涤器的水位设置调到最高选项并运行机器。断开过滤器。如果水没有倒出来，就会堵塞。

If this is the case, fill your solution tank with warm water and a cup of bleach. Let it sit overnight, then disconnect the filter to see if it drains. 

Note: Do not run your machine with bleach.

如果是这种情况，请用温水和一杯漂白剂填充溶液罐。让它静置一夜，然后断开过滤器，看看它是否排水。请注意： 请勿使用漂白剂运行机器。

If after this floor scrubber troubleshooting your machine still isn’t releasing water, the issue may be the solution valve.

This is more complicated and requires professional floor machine repair.

如果在此洗地机故障排除后，您的机器仍然没有放水，则问题可能出在解决方案阀上。这比较复杂，需要专业的地板机器维修。

Floor Scrubber Not Picking Up Water
洗地机不吸水

Is your floor scrubber not picking up water? Automatic floor scrubbers have a system in place to pick up the water once the scrubbing i

s done. If your scrubber is leaving behind excessive amounts of water, something may be wrong.

您的洗地机不吸水吗？自动洗地机有一个系统，可以在擦洗完成后收集水。如果您的洗涤器留下了过多的水，则可能有问题。

First, check your recovery tank to make sure it isn’t full. The recovery tank is responsible for holding dirty water and solution.

Empty the tank and use your equipment to see if the floor scrubber not picking up water is still an issue.

首先，检查您的回收罐以确保它没有装满。回收罐负责盛装脏水和溶液。清空水箱并使用您的设备查看洗地机是否仍然不吸水。

If that isn’t the solution, try unclogging the vacuum hose.

You can do this with a standard broom. Just stick the handle down the hose and flush it out with water.

You can also try emptying the debris tray.

如果这不是解决方案，请尝试疏通真空软管。您可以使用标准扫帚来做到这一点。

只需将手柄伸入软管并用水冲洗即可。您也可以尝试清空杂物托盘。

If none of the floor scrubber troubleshooting works,

you may need to take your equipment to a professional servicing company.

如果洗地机故障排除不起作用，您可能需要将设备带到专业维修公司。